区域供应

quyugongying

当前位置:网站首页 > 区域供应 > 正文

环氧地板漆施工处理地面需要注意的安全措施

东柏地坪漆 2019-05-10 161 0

环氧地坪漆施工施工前,基础地面处理是环氧地坪漆工程中重要环节之一,当被涂表面有不平整、有凹坑,裂缝、孔隙时,会影响涂层外观质量。基础地面处理主要工艺就是清洁、除油、除漆、干燥等环氧地坪表面,较为常用所采用的化学品都具有较高的毒性和腐蚀性。然而是用抛丸、高压水处理技术又要求施工人员具备较高的操作水平。现在就对环氧地坪漆在基面处理中安全措施来做下了解,加强防范意识,减少安全隐患的发生,保证施工人员的人身安全。

Before the construction of epoxy floor paint, the foundation ground treatment is one of the important links in the epoxy floor paint engineering. When the surface is uneven, pitted, cracked and porous, it will affect the appearance quality of the coating. The main processes of basic ground treatment are cleaning, degreasing, paint removal, drying and other flooring surfaces. The commonly used chemicals are highly toxic and corrosive. However, the use of shot blasting and high-pressure water treatment technology also requires that the construction personnel have a higher level of operation. Now we will understand the safety measures of epoxy floor paint in the foundation treatment, strengthen the awareness of prevention, reduce the occurrence of potential safety hazards, and ensure the personal safety of construction personnel. (1)基面处理时对防火、防爆、防毒等都应该要严格预防。苯、甲苯、二甲苯和汽油都是在进行大面积除油和清除旧涂膜作业中禁止使用的。一般都采用水性清洗液或水溶性脱漆剂代替。

(1) Fire, explosion and poison prevention should be strictly prevented when dealing with the base surface. Benzene, toluene, xylene and gasoline are forbidden to be used in large-scale oil removal and old film removal operations. Usually water-based cleaning solution or water-soluble paint remover is used instead.

环氧地板漆施工处理地面需要注意的安全措施

(2)手工进行基面处理之前,首先要检查机器的可靠性,相邻操作的工作人员的间距不少于1m。

(2) Before the base surface treatment is done manually, the reliability of the machine must be checked first. The distance between adjacent workers is not less than 1m.

(3)使用机械方法清除旧漆时候,必须要设置独立的排风系统和除尘装置,对于空气中的粉尘含量不大于150mg/m3。

(3) When using mechanical method to remove old paint, it is necessary to set up an independent ventilation system and dust removal device. For the dust content in the air is not more than 150 mg/m.

(4)电动、风动或液压打磨工具,要按照所选的磨片材料限制机械的速度,进行基面处理之前要先做空载试转2分钟,检查工具的可靠性。并在机械使用了一段时间后,检查其磨具的材质消耗,以保障其正常运作。

(4) For electric, pneumatic or hydraulic grinding tools, the speed of the machine should be limited according to the selected abrasive material, and the reliability of the tool should be checked by no-load test run for 2 minutes before base surface treatment. After the machine has been used for a period of time, the material consumption of its abrasives is checked to ensure its normal operation.

(5)用可燃性有机溶剂除油时,必须在施工地显眼的地方设标牌,并且配置可燃气体快速测量仪进行定期检测。

(5) When removing oil with flammable organic solvents, a sign must be set up in the place where the construction is conspicuous, and a flammable gas rapid measuring instrument must be equipped for periodic detection.

基础地面表面处理是清除表面污物,修补凸凹不平,裂缝、孔隙、不平整的基面,增强涂层对基面的附着力,充分发挥涂层的保持作用,延长涂层使用寿命,提高涂层良好的装饰性。当地面有油污、水分时,由于油和水与涂料形成不相容的问题,难以施工即使形成了完成的涂层,也会大大降低附着力,使环氧地坪漆涂层过早脱落;当地板表面有杂物和砂粒时,使涂层产生麻点,严重影响外观;地坪漆涂装前表面处理的首要目的是清除表面污物,同时,只有在处理清洁后、平整的基材表面,才有可能涂装一个光滑、平整、美观的地坪漆工程,才能保证涂层有良好的装饰性与耐磨性。

环氧地板漆施工处理地面需要注意的安全措施

Base surface treatment is to remove surface dirt, repair uneven, cracked, porous, uneven base, enhance the adhesion of the coating to the base, give full play to the role of coating maintenance, prolong the service life of the coating, improve the decorative properties of the coating. When there is oil and water on the floor, because of the incompatibility between oil and water and paint, it is difficult to construct even if the finished coating is formed, it will greatly reduce the adhesion and make the floor paint coating fall off prematurely; when there are sundries and sand particles on the surface of the floor, the coating will produce pitting, which seriously affects the appearance; the primary purpose of surface treatment before painting is to remove surface dirt, and at the same time, to remove surface dirt. Only when the clean and flat surface of the base material is treated can it be possible to coat a smooth, flat and beautiful floor paint project, so as to ensure that the coating has good decorative and wear resistance.


相关推荐

  • 混凝土地面起砂还能做环氧地板漆吗?

    混凝土地面起砂还能做环氧地板漆吗?

    环氧地板漆具有无接缝、耐腐蚀、防尘防水、维护方便和强度高、耐磨损等优点,而且颜色多样,装饰性非常强,因而被广泛应用于厂房车间、地下停车场等。在选择做环氧地板漆的时候,有时候会遇到混凝土地面起砂的现象,这时候消费者就会有疑问:混凝土地面起砂还...

    2019-05-20 107 0

  • 停车场地板漆

    停车场地板漆

    停车场地坪漆颜色多样可根据客户的要求对地坪进行设计规划,特别是一些大型的地下停车场地坪翻新改造,立体车库的地面,商业大厦的地下停车场等都可以采用停车场地坪漆进行涂装,增加车库地面的美观感和整洁度。适用范围:① 适用于各种地下停车场...

    2019-05-04 133 0

  • 影响地板漆价格的因素

    影响地板漆价格的因素

    地板漆的优点很多可以应用在很多场所。比如说地下商业街面积非常大,如果选择铺设瓷砖,造价就会非常高。而直接水泥铺地不作处理那是不可能的,不仅不美观还会出现灰尘,也不耐用,而地板漆价格居中,既美观有耐用,所以我国地坪漆的使用率也越来越高。不同种...

    2019-04-25 112 0

  • 砂浆型环氧地板漆

    砂浆型环氧地板漆

    产品说明:砂浆型环氧地坪采用进口环氧树脂和固化剂作为基材进行施工。比普通环氧树脂地坪的耐磨和耐压性能更好。砂浆型环氧地坪是由特种环氧树脂添加适当溶剂,填料,表面活性剂和高级颜料等材料做为主剂,并采用改性脂肪胺做为固化剂,在常温条件下所形成的...

    2019-04-19 135 0

  • 贷款利率下降有助于推动水泥地板漆行业发展

    贷款利率下降有助于推动水泥地板漆行业发展

    央行于2014年11月21日晚间宣布降息。此次降息采取的是:不对称降息,金融机构一年期贷款基准利率下调0.4个百分点,调整为5.6%,一年期存款利率下调0.25个百分点,调整为2.75%,同时结合推进利率市场化改革,将金融机构存款利率浮动区...

    2019-04-15 140 0

  • 地板漆价格与品牌有何关系?

    地板漆价格与品牌有何关系?

    据水泥地板漆研究院的专家介绍,对于一个企业的产品而言,一个产品的品质是品牌的基础,对于产品品质可能是道听途说的,可能是自己亲身体会过,可能是看过宣传广告。不管你从那些方面或那种形式了解一件产品,环氧树脂地坪的品质不能片面地从看某一方面看待,...

    2019-04-08 113 0

本文暂时没有评论,来添加一个吧(●'◡'●)

欢迎 发表评论: